In southwestern Michigan and in North Hollywood, CA I had one of three guy
anchors rust just as described. 10 years in Michigan, 5 years in CA.
de Paul, W8AEF
----- Original Message -----
From: "Tom Frenaye" <frenaye@pcnet.com>
To: <towertalk@contesting.com>
Sent: Tuesday, April 29, 2003 5:24 AM
Subject: [TowerTalk] anchor failure from corrosion?
>
> I hadn't ever heard of guy anchors on ham radio towers failing because of
corrosion I'm wondering if it's something all of us need to worry about -
anyone with firsthand experience?
>
> -- Tom
>
>
> > HELPFUL ADVICE ON GUY ANCHOR INSPECTIONS (CGC #570)
> >
> > Over the years there have been numerous instances of towers
> >falling due to guy anchor failure, with guy wires hanging on to
> >as little as 1/4" of remaining shaft before failure.
> >
> > As a Tower Safety and Rescue trainer for our company, I have
> >taken trainees to a guyed tower to see the "point of daylight."
> >This is where the guy anchor meets the dirt, and is the most
> >likely place to reveal corrosion just below the surface, as shown
> >in the diagram of CGC #570. Dig down about 6-12 inches and you
> >may likely find the beginnings of corrosion. This inspection
> >should be performed regularly if you own a guyed tower.
> >
> > The best way to prevent or delay the corrosion process is
> >through the use of a "Sacrificial Anode" - or Cathodic Protection.
> >You can see the process of corrosion and how it can be prevented
> >in these instructional animations courtesy of www.anchorguard.com:
> >
> > Corrosion: http://www.anchorguard.com/images/Corrosion.gif
> > Protection: http://www.anchorguard.com/images/protection.gif
> >
> > Timothy H. Lynch, mailto:tlynch@w-t-s.com
> > Western Technical Services
>
> > THE CGC COMMUNICATOR
> > CGC #572
> > Tuesday, April 29, 2003
> > ________
> >
> > Robert F. Gonsett, W6VR, Publisher
> > <rgonsett@ieee.org>
> >
> > Stephen H. Blodgett, W7RNA, Letters Editor
> > mailto:steve@earthsignals.com
> >
> > Copyright 2003, Communications General? Corporation (CGC)
>
>
>
> --------------------------------------------------------------------------
------------------------------------------
> e-mail: frenaye@pcnet.com YCCC --> http://www.yccc.org/
> Tom Frenaye, K1KI, P O Box J, West Suffield CT 06093 Phone: 860-668-5444
>
>
>
> _______________________________________________
>
> See: http://www.mscomputer.com for "Self Supporting Towers", "Wireless
Weather Stations", and lot's more. Call Toll Free, 1-800-333-9041 with any
questions and ask for Sherman, W2FLA.
>
> _______________________________________________
> TowerTalk mailing list
> TowerTalk@contesting.com
> http://lists.contesting.com/mailman/listinfo/towertalk
|
