I have been using 24 volts on 12 volt coil relays for years and I have never
had a failure. Occasionally I have left a switch on with a relay energized
for as long as a week. The higher voltage also compensates for resistance
in the lines to the relay too.
Chuck W5PR
-----Original Message-----
From: towertalk-bounces@contesting.com
[mailto:towertalk-bounces@contesting.com] On Behalf Of w9ge
Sent: Wednesday, December 08, 2004 1:52 PM
To: towertalk@contesting.com
Subject: Re: [TowerTalk] (another)Problem That Needs Ideas
I have a two port six pack that I have relegated to the back bench because
of relays not always pulling in. It is tough on amplifier tubes to be
running into an open! My rotator has no brake, so cannot try that method.
A very light touch on the offending relay always makes em pull in however.
73 bob de w9ge
----- Original Message -----
From: <n4gi@tampabay.rr.com>
To: <towertalk@contesting.com>
Sent: Wednesday, December 08, 2004 8:06 AM
Subject: Re: [TowerTalk] (another)Problem That Needs Ideas
> Don't have an RCS8V, but it reminds me of a problem I occasionally
> have with a sixpack switch... One or two of the ports on one side are
> intermittent unless I click the brake of my ham rotor 50 feet above it.
>
> If I don't hear anything when I turn things on, I can click the brake
> a couple of times, then the relay engages. I think it's the 10M port.
>
> Odd, but I just have lived with it. Dirty contacts?
>
> 73,
> Blake N4GI
>
> ----- Original Message -----
> From: Bill Jackson <k9rz@radiks.net>
> Date: Tuesday, December 7, 2004 8:21 pm
> Subject: Re: [TowerTalk] Problem That Needs Ideas
>
>> Pat,
>>
>> I have an Ameritron RCS-8V which has been in service for almost 20
>> years.Shortly after I purchased it new, I started having intermittant
>> problems similar to yours, especially in cold weather. This was the
>> case until I discovered the relay arms were touching the inside of
>> the plastic cover and would only partially actuate. The cure was to
>> place a couple of flat washers between the plastic case the and the
>> chassis in all four corners,increasing the clearance between the case
>> and the relays.
>> It has operated
>> flawlessly ever since.
>>
>> I would try operating the switch with the cover off to see how the
>> relaysactuate.
>>
>> 73 de Bill
>>
>>
>> _______________________________________________
>>
>> See: http://www.mscomputer.com for "Self Supporting Towers",
>> "Wireless Weather Stations", and lot's more. Call Toll Free, 1-
>> 800-333-9041 with any questions and ask for Sherman, W2FLA.
>>
>> _______________________________________________
>> TowerTalk mailing list
>> TowerTalk@contesting.com
>> http://lists.contesting.com/mailman/listinfo/towertalk
>>
>
> _______________________________________________
>
> See: http://www.mscomputer.com for "Self Supporting Towers",
> "Wireless Weather Stations", and lot's more. Call Toll Free,
> 1-800-333-9041 with any questions and ask for Sherman, W2FLA.
>
> _______________________________________________
> TowerTalk mailing list
> TowerTalk@contesting.com
> http://lists.contesting.com/mailman/listinfo/towertalk
>
_______________________________________________
See: http://www.mscomputer.com for "Self Supporting Towers", "Wireless
Weather Stations", and lot's more. Call Toll Free, 1-800-333-9041 with any
questions and ask for Sherman, W2FLA.
_______________________________________________
TowerTalk mailing list
TowerTalk@contesting.com
http://lists.contesting.com/mailman/listinfo/towertalk
_______________________________________________
See: http://www.mscomputer.com for "Self Supporting Towers", "Wireless Weather
Stations", and lot's more. Call Toll Free, 1-800-333-9041 with any questions
and ask for Sherman, W2FLA.
_______________________________________________
TowerTalk mailing list
TowerTalk@contesting.com
http://lists.contesting.com/mailman/listinfo/towertalk
|