Marshall, I would go with Gerald's suggestion, and then go one step farther.
It would be a great time to pull that 'ol tailtwister apart and make sure
Katrina didn't do some internal damage. It could save you trouble in the long
run.
73
Jake K9WN
Message: 5
Date: Tue, 13 Sep 2005 21:17:38 EDT
From: TexasRF@aol.com
Subject: Re: [TowerTalk] How to weather seal a Tailtwister rotor?
To: w4emb@myacc.net, towertalk@contesting.com
Message-ID: <143.4cdc2a50.3058d432@aol.com>
Content-Type: text/plain; charset="US-ASCII"
Marshall, even if you were able to weather seal the rotator there is still
the problem of moisture condensation inside the unit due to the heating/cooling
cycle from day to night. The condensation will collect and the same trouble
will occur.
The only safe option is to remove the rotator and store it inside where
there is some humidity control or at least store it right side up so
condensation
can run out of the unit.
73,
Gerald/K5GW
In a message dated 9/13/2005 6:27:24 P.M. Central Standard Time,
w4emb@myacc.net writes:
Hello all,
I have a Tailtwister (TX-2) rotor mounted on a Rohn 25 foldover tower.
While the tower itself appears to have survived intact, hurricane
Katrina snapped the mast and destroyed the antennas. I need to fold the
tower over to work in it, and likely leave it folded over for a fairly
extended period. This will leave the top of the tower and the rotor
upside down. Unfortunately, it is still the rainy season here, and the
last time I needed to do this, rain water got into the rotor and settled
in the bell, causing rust and other corrosion damage inside the rotor,
because it is only weather protected when it is upright. I would like
to seal the rotor while the tower is folded over to prevent this from
happening again, but none of the ideas I've had so far (wrapping it in
plastic garbage bags, using duct tape, using sealing foam) are usable,
either because they don't seal well enough to keep water out or because
sealing stuff may get up inside the rotor where I can't get it out.
So, does anyone have any suggestions?
73, Marshall - W4EMB
_______________________________________________
See: http://www.mscomputer.com for "Self Supporting Towers", "Wireless Weather
Stations", and lot's more. Call Toll Free, 1-800-333-9041 with any questions
and ask for Sherman, W2FLA.
_______________________________________________
TowerTalk mailing list
TowerTalk@contesting.com
http://lists.contesting.com/mailman/listinfo/towertalk
|