K9RB wrote:
>If this is unsuccessful another alternative is to drill a couple of
>5/32"-3/16" drain holes in each affected leg, as close to the concrete as
>you can get, and check that these holes remain open every couple of weeks by
>inserting something into these holes and/or observing actual drainage. (They
>WILL periodically plug up, and you'll not want to ever let this happen,
>especially when subjected to freezing temps.)
If you follow this suggestion, which isn't all that bad, consider
'filling' the hole with NYLON CORD. Put about 1" of cord halfway
thru the hole (actually, put HALF of the cord thru the hole), and
this way, any accumulated water can 'wick' out, but dirt, and critters
can't get into the leg.
73 - Tom Hammond N0SS
>You'll also want to apply some tar from the bottom of the holes to to
>concrete, encapsulating the entire exposed leg, below the holes, to retard
>the rusting of the leg/s at this point from the (more present) moisture.
>(Thats always a good idea anyways where the legs go into the concrete.) 73 &
>Good Luck, -=Rog-K9RB=-
>Don't let the callsign fool ya.....I'm in Northern Florida, where the
>temperature got down to 24 degrees on two mornings this past winter. So I'm
>sure you experience freezing temps. in Virginia too!
>-----Original Message-----
>From: Richard Eckman <ko4mr@arrl.net>
>To: towertalk@contesting.com <towertalk@contesting.com>
To: <towertalk@contesting.com>
>Date: Wednesday, April 14, 1999 8:55 PM
>Subject: [TowerTalk] Tower base drainage problem
>
>
>>
>>I recently installed a 30' Universal tower. Before pouring the concrete
>>into the appropriately sized hole, I added several inches of crushed rock
>>to the bottom of the hole for drainage of the base legs. Sometime after
>>pouring the concrete, I noticed that two of the three bases legs (which are
>>largely embedded in the concrete) were not draining. I could see water in
>>the legs nearly up to the top, just below where the hinged base attaches to
>>the bottom tower section..
>>
>>I'm assuming that in pouring the concrete, the contractor and I somehow
>>managed to get some of it under the legs, even with the several inches of
>>drainage rock, thus preventing adequate water drainage.
>>
>>My question is whether anyone has a feeling of how serious a problem this
>>lack of water drainage is. Will this prolonged exposure of the steel legs
>>to water likely cause any structural integrity problems?
>>
>>Richard Eckman KO4MR
>>Hampton, VA
>>ko4mr@arrl.net
>>
>>
>>--
>>FAQ on WWW: http://www.contesting.com/towertalkfaq.html
>>Submissions: towertalk@contesting.com
>>Administrative requests: towertalk-REQUEST@contesting.com
>>Problems: owner-towertalk@contesting.com
>>Search: http://www.contesting.com/km9p/search.htm
>>
>
>
>
>
>
>
>
>--
>FAQ on WWW: http://www.contesting.com/towertalkfaq.html
>Submissions: towertalk@contesting.com
>Administrative requests: towertalk-REQUEST@contesting.com
>Problems: owner-towertalk@contesting.com
>Search: http://www.contesting.com/km9p/search.htm
>
>
--
FAQ on WWW: http://www.contesting.com/towertalkfaq.html
Submissions: towertalk@contesting.com
Administrative requests: towertalk-REQUEST@contesting.com
Problems: owner-towertalk@contesting.com
Search: http://www.contesting.com/km9p/search.htm
|