Mark, I find it hard to believe, as we have sold these for 2 years and not
experienced these problems. Why don't you talk to Yaesu tech support and try
and figure out what is causing these resistors to heat up and burn out? The
traces on the board are obviously burning out due to excessive current from too
big a sized resistor being installed. But what is causing all this current?
Something doesn't sound right. What are you turning with it?
Which resistors are burning out, i'll look at our service manuals on it and see
what I can find out for you.
Scott
KA1CLX
At 10:57 PM 2/14/99 -0600, you wrote:
>
>Hi All Again
> Just replaced the 2 resistors in the control box of the
>g800 AGAIN, this time with 120 ohm 2 watters, if they go I
>am going to chuck this piece of s__t out the door & put up
>the ham 4.
> Mark
>ps:the last set of 120ohm 1 watters lasted less than 2
>weeks, Yaesu claims their aren't any problems with the
>design of the g800s control box, the first set of resistors
>died at 3 months (they supplied replacements) the second at
>13 months (send it in we will fix it for around $100), this
>is now the 6th pair of resistors & the control board has
>burnt through so bad that I have had to replace traces with
>wire! The g800s control box is JUNK!!!
>
>Douglas Bradford wrote:
>>
>> Andy Wallace wrote:
>> >
>> > Steve--
>> >
>> > The clutch would only let loose in dangerously high winds. I'd rather
>> > replace a
>> > coax connection then worry with a tower twisted down--I think it would be a
>> > little cheaper.
>> >
>> > Andy K5VM
>>
>> If the wind is high enough to twist the Tower, I would think everything
>> else would be gone. You are speaking of Tornado type wind.
>>
>> 73 Brad KZ5Q
>>
>> --
>> FAQ on WWW: http://www.contesting.com/towertalkfaq.html
>> Submissions: towertalk@contesting.com
>> Administrative requests: towertalk-REQUEST@contesting.com
>> Problems: owner-towertalk@contesting.com
>> Search: http://www.contesting.com/km9p/search.htm
>
>--
>FAQ on WWW: http://www.contesting.com/towertalkfaq.html
>Submissions: towertalk@contesting.com
>Administrative requests: towertalk-REQUEST@contesting.com
>Problems: owner-towertalk@contesting.com
>Search: http://www.contesting.com/km9p/search.htm
>
>
>
<bold><bigger>
Advantage Communications
</bigger></bold>Professional Wireless Communications
www.advantagecomm.net
978-568-1944
--
FAQ on WWW: http://www.contesting.com/towertalkfaq.html
Submissions: towertalk@contesting.com
Administrative requests: towertalk-REQUEST@contesting.com
Problems: owner-towertalk@contesting.com
Search: http://www.contesting.com/km9p/search.htm
|