The consensus was to use solid FR4 G10 rod.
These guys sell it and I believe that they can do the machining required.
http://www.jjorly.com/g10_rod_rods.htm
----- Original Message -----
From: "Allen R. Brier" <n5xz@earthlink.net>
To: <towertalk@contesting.com>
Cc: "'Rick Hiller'" <rhiller@sdicgm.com>
Sent: Monday, 13 April, 2009 3:39 PM
Subject: [TowerTalk] Rohn 20/25G leg insulator material
>I wish to build an 80 meter vertical using some Rohn 20G sections I have in
> storage. In the past there was some mention of insulating material that
> could be used at the base. If possible, I would like to get that
> information
> again from the group. I would like to make the vertical self supporting
> i.e.
> no guys (bosses request). Will the material be strong enough for that?
>
> In addition, what would be a good recommendation for the vertical
> configuration, i.e. how many 20G sections and how much of a stinger on
> top?
> Obviously maximum bandwidth and efficiency is the goal and I operate
> mostly
> CW.
>
> Next, I would also like to consider using the same antenna on 160 meters,
> by
> switching in a loading coil at the bottom. I know this isn't optimal, but
> I
> would like some recommendation for how much inductance in would need, or
> the
> coil configuration (full legal limit, of course). Other recommendations
> would also be appreciated.
>
> Finally, I also have a 70 foot crank-up tower with a 4-el SteppIR on top
> that could be shunt fed. If I did shunt feed the tower, what would be the
> optimal distance between them for phasing purposes?
>
> A lot and questions in one email but I would appreciate any and all
> advice.
>
> 73,
>
> Allen Brier N5XZ / KL5DX
> 1515 Windloch Lane
> Richmond, TX 77406-2533
> 281-342-1882
> 713-705-4801 (Cell)
> n5xz@arrl.net
>
> _______________________________________________
>
>
>
> _______________________________________________
> TowerTalk mailing list
> TowerTalk@contesting.com
> http://lists.contesting.com/mailman/listinfo/towertalk
_______________________________________________
_______________________________________________
TowerTalk mailing list
TowerTalk@contesting.com
http://lists.contesting.com/mailman/listinfo/towertalk
|