[TenTec] Orion II Won't Power Up

[Bernie Skoch]

Thanks, Gary.

Do you happen to have a parts location diagram?
I can see a couple of diodes beneath the circuit board mounted SO-239s on the board, but I don't want to remove both of those connectors unless absolutely necessary.  I assume D116 is one of those?

-----Original Message-----
From: Gary Follett <dukeshifi at comcast.net>
To: Discussion of Ten-Tec Equipment <tentec at contesting.com>
Sent: Sat, Jan 18, 2020 10:03 pm
Subject: Re: [TenTec] Orion II Won't Power Up

Added info: If D116 is shorted, it will not pop the fuse because it is looking at a 1K load resistor. If you did get a transient at the antenna, it is not unreasonable to think that D116 would fail.


It is possible Q77 failed as well but that is a really common 2N3904.

Gary



> On Jan 18, 2020, at 9:55 PM, Bernie Skoch via TenTec <tentec at contesting.com> wrote:
> 
> Thanks.  Where and what type is D116?
> 
> 
> -----Original Message-----
> From: Gary Follett <dukeshifi at comcast.net>
> To: Discussion of Ten-Tec Equipment <tentec at contesting.com>
> Sent: Sat, Jan 18, 2020 9:47 pm
> Subject: Re: [TenTec] Orion II Won't Power Up
> 
> The 5KP15A device is designed specifically to protect sensitive electronic equipment from voltage transients induced by lightning and other transient voltage events. Its job it is to short the supply of the transient to ground in a picosecond (1E-12 seconds).
> 
> Failure of this part in the open mode would have no effect on radio operation. If shorted, it would pop the main fuse, but only if the relay K1 were on. Since you do not hear that relay clicking on, the transient suppressor is not even in the circuit.
> 
> If D116 were shorted, it would put Q77 base high, pulling Q23 base low. This would override the Power Switch turn on signal at J8 on the I/O board and this would prevent the power switch from turning the radio on.
> 
> Gary
> 
> W0DVN
> 
>> On Jan 18, 2020, at 9:14 PM, Bernie Skoch via TenTec <tentec at contesting.com> wrote:
>> 
>> 5KP15A
> 
> _______________________________________________
> TenTec mailing list
> TenTec at contesting.com
> http://lists.contesting.com/mailman/listinfo/tentec
> _______________________________________________
> TenTec mailing list
> TenTec at contesting.com
> http://lists.contesting.com/mailman/listinfo/tentec

_______________________________________________
TenTec mailing list
TenTec at contesting.com
http://lists.contesting.com/mailman/listinfo/tentec