[TowerTalk] Rohn 25g rotor plate mounting question

Rajiv Dewan, N2RD n2rd@arrl.net
Fri, 8 Oct 1999 12:54:28 -0400


I have a similar setup and you are dead-on.  I have the rotor mounted at the
joint between the top and next to top section.  My top section is a flat top
thrust bearing compatible section and so I have a thrust bearing at the top
of the tower and rotor 8 feet below that.  I purchased an extra rotor shelf,
notched it to fit four feet down and put a cheapo Yaesu thrust bearing on it
just to help with installation.  My mast is 24' long, 8 feet in the top
section and 16 feet above.  It did not want it flopping around during rotor
installation and put huge stresses on the thrust bearing and that is the
only use of the intermediate bearing.  I leave it loose during normal
operation.
  Hope this helps,
Rajiv, N2RD
----- Original Message -----
From: Nat Davis <ndavis@vt.edu>
To: <towertalk@contesting.com>
Sent: Friday, October 08, 1999 11:55 AM
Subject: [TowerTalk] Rohn 25g rotor plate mounting question


>
> My Rohn 25G 30' house bracketed tower is almost up and time to start
> thinking about putting "stuff" on it...  Here is my newbie question for
the
> week.
>
> Per a recent suggestion on towertalk, I want to mount the rotor down from
> the very top of the tower so it is somewhat easier to get to...  However,
> The rotor plate seems made to fit only across the top of the side bracing
> at the very top end of a tower section.  The plate u-bolts to the tower
> legs and it appears that if I try to attach the plate to a point in the
> middle of a section, the vertical pieces of the bracing will get in the
> way.  The only ways around this would seem to be to attach the plate at
the
> top of the next to the last section (requiring a >10' mast just to clear
> the top of the tower) or to cut notches in the plate so that it clears the
> vertical sections of the bracing (would require bolting the plate to the
> horizontal bracing rather than the tower legs).
>
> Am I wrong in this?  Suggestions?
>
> Thanks,
>
> Nat
> N4EL
>
>
> --
> FAQ on WWW:               http://www.contesting.com/towertalkfaq.html
> Submissions:              towertalk@contesting.com
> Administrative requests:  towertalk-REQUEST@contesting.com
> Problems:                 owner-towertalk@contesting.com
> Search:                   http://www.contesting.com/km9p/search.htm
>


--
FAQ on WWW:               http://www.contesting.com/towertalkfaq.html
Submissions:              towertalk@contesting.com
Administrative requests:  towertalk-REQUEST@contesting.com
Problems:                 owner-towertalk@contesting.com
Search:                   http://www.contesting.com/km9p/search.htm