Towertalk
[Top] [All Lists]

Re: [TowerTalk] A couple of 18HT questions

To: Allen Brier N5XZ <n5xz@earthlink.net>, Robie Elms <ruler55@gmail.com>
Subject: Re: [TowerTalk] A couple of 18HT questions
From: Chris <ezrhino@fastmovers.biz>
Date: Tue, 16 Dec 2014 19:11:52 -0700
List-post: <towertalk@contesting.com">mailto:towertalk@contesting.com>
Right, Universal aluminum towers use a galvanized steel concrete base (I have 
one).

Chris
KF7P

---- Robie Elms <ruler55@gmail.com> wrote ----

>Allen,
>
>I have no personal experience with attaching aluminum structure to
>concrete.  However, Universal tower states that this is a problem.  See the
>following link:  http://www.universaltowers.com/I-B.pdf
>
>I have installed a tremendous number of structures over the years. Towers,
>pipe racks, structures to hold vessels, etc. and have never seen aluminum
>in direct with concrete.  When aluminum is involved, galvanized steel was
>in contact with the concrete.
>
>Robie - AJ4F
>
>On Tue, Dec 16, 2014 at 11:51 PM, Allen Brier N5XZ <n5xz@earthlink.net>
>wrote:
>>
>> I have the hole dug for my new 18HT tower but still a few more questions:
>>
>>
>>
>> 1.       The base consists of three 1.75 in by 0.25 in thick aluminum "base
>> tubes" with long bolts on the bottom which is pushed into the concrete
>> immediately after the pour. Is there any problem with the aluminum
>> contacting the concrete producing any kind of adverse chemical reaction?
>>
>> 2.       The rods only go into the concrete perhaps 18 to 24 in. Is that
>> sufficient to hold the tower in the concrete?
>>
>> 3.       I have been told that the PVC insulators which are at the top of
>> the top tower section should be replaced with Teflon due to high voltage at
>> that point while using the antenna on 160 meters with the base loading
>> coil.
>> (Note I plan to use a larger physical coil than Hy-Gain recommends). Any
>> truth to that?
>>
>>
>>
>> That is all for now.
>>
>>
>>
>> Allen R. Brier N5XZ
>>
>> 1515 Windloch Lane
>>
>> Richmond, Texas 77406-2553
>>
>> (281) 342-1882 (Home)
>>
>> (713) 705-4801 (Cell)
>>
>>
>>
>> _______________________________________________
>>
>>
>>
>> _______________________________________________
>> TowerTalk mailing list
>> TowerTalk@contesting.com
>> http://lists.contesting.com/mailman/listinfo/towertalk
>>
>_______________________________________________
>
>
>
>_______________________________________________
>TowerTalk mailing list
>TowerTalk@contesting.com
>http://lists.contesting.com/mailman/listinfo/towertalk
>
_______________________________________________



_______________________________________________
TowerTalk mailing list
TowerTalk@contesting.com
http://lists.contesting.com/mailman/listinfo/towertalk

<Prev in Thread] Current Thread [Next in Thread>